Top Tips for Cold-Weather Starts

Icy dump

 

As the temperatures drop into single digits or lower, batteries lose their cranking power and can fail. Here are a few winter starting tips to extend battery life.

Top Tip No. 1: Turn the lights on before cranking the engine

If the temperature drops to single digits or colder, run the four-way or emergency flashers for 15 to 20 seconds before starting the vehicle. Another option is to turn the headlights on for the same amount of time. This helps to energize a chilled battery.

Caution: Be sure to turn any lights off before cranking the starter. The electrical current load while starting or cranking an engine can burn out the light bulbs or cut the life of the lights in half.

Top Tip Number 2: Heat your diesel’s aluminum air-intake pipe

Diesels do not have spark plugs; they ignite fuel by heating up air blended with a mist of diesel fuel. If your diesel engine does not have a block heater (or it fails or wasn’t plugged in), one way to help get the engine going on a cold day is to heat the aluminum air-intake pipe. Aluminum melts easily, so be sure to fan the heat over the pipe.

Caution: If you are not sure what to do or what the aluminum air-intake pipe is or where to find it, then do not attempt this.

Top Tip Number 3: The 24-hour Battery Recharge

In making short trips around town, the battery might not get fully charged. If the battery is totally run-down, it might need to be re-charged. For a lead-acid battery, this won’t happen in ten to fifteen minutes. A recommended practice is to charge the battery for 24 hours to fully charge the battery. Follow the instructions on your battery charger or any tips from the battery maker.

Top Tip Number 4: Wear Proper Personal Protection Equipment (PPE)

Always wear safety glasses and gloves if working with batteries. If working around batteries or recharging batteries or jumping batteries, sparks and hydrogen can occur and this might result in a battery explosion. Battery acid in the eyes can result in blindness.

Top Tip Number 5: Never Drop a Battery

Dropping a battery can kill it. Dead. Never drop a lead-acid battery. Treat batteries with the respect they deserve and they will never fail you.

The technology of the lead-acid battery has not changed much in the last sixty years or so. But a vehicle’s batteries can last the life of a vehicle, if properly maintained and managed.

Encountering Ice While Driving

Jan. 9, 2015 I-94 Pileup near Galesburg, MI

NPR reported on a pileup involving 123 cars and trucks, several hauling hazmat, which resulted in one fatality, 23 people injured, fire and explosions.

Driver Ryan Bovee, who was involved in what seems to have been one of the first collisions, said the trouble began around 9:15 this morning, just after he realized that most of the road was coated by ice. Not long afterward, a van hit the rear of his car, and he hit the car in front of him.

Ice is not Nice

In cold weather, we can anticipate encountering patches of ice while driving. But if you find yourself on ice, do you know what to do? Here a few tips:

1. Do Not Panic

The number one job of a driver is to maintain control and to focus on driving the vehicle. Continue to drive the vehicle.

2. Don’t Hit the Brakes Hard

It’s natural to want to slow down and regain control of the situation. Hitting the brakes hard can pitch your vehicle forward, resulting in a skid and loss of control. Brake gently, if you need to brake at all.

What about Antilock Braking Systems (ABS?) eHow.com says:

Effects of Ice on ABS

  • On roads that are partially covered by ice, ABS can help the driver stop and steer the vehicle more effectively, provided he keeps the brake pedal depressed, and does not pump the brakes. Under severe conditions when the entire road is covered with ice, all four wheels may lock simultaneously. Unless at least one wheel is turning, the ABS will react as if the vehicle has stopped. When this occurs, the ABS is defeated, and the driver will need to go back to the pumping technique.

With ABS — don’t pump the brakes — but if all four wheels lock up, the vehicle could still go into a skid, so unlock the wheels by momentarily releasing the brake pedal. How would know if all of the wheels are locked-up? Your vehicle will start to skid.

A skid occurs when at least one wheel is locked up, or from uneven tire rotation (due to tires that are spinning, or from hydroplaning on slush, wet snow, or water). ABS prevents skids by keeping the wheels from locking up.

Federal Motor Vehicle Safety Standard No. 121, Air Brake Systems, mandates antilock braking systems on air-braked vehicles with a GVWR of 10,000 pounds or greater. ABS is required on tractors manufactured on or after March 1, 1997, and air-braked semitrailers and single-unit trucks manufactured on or after March 1, 1998.

In a 2010 report (opens in .pdf) called The Effectiveness of ABS in Heavy Truck Tractors and Trailers, by the National Highway Traffic Safety Administration, it was found:

Among the types of crashes that ABS influences, there is large reduction in jack-knives, off-road overturns, and at-fault involvements in collisions with other vehicles (except front-to-rear collisions). Counteracting are an increase in the number of involvements of hitting animals, pedestrians, or bicycles and, only in fatal crashes, rear-ending lead vehicles in two-vehicle crashes.

In short, ABS increases the risk for trucks in rear-ending another vehicle. Drivers need to be aware of this and need to adapt their driving habits:

  • Increase following distances, more so in bad weather;
  • Gently apply the brakes, idling to a stop;
  • Anticipate longer stopping distances.

Truck drivers need to watch the trailer when braking on ice. If the wheels lock up, a trailer can start to swing around.

3. Cut Power to the Drive Wheels: Declutch or Put the Shifter in Neutral.

Suddenly taking the foot off of the fuel pedal while on ice can induce a skid. Cutting power to the wheels by putting in the clutch or, for an automatic, placing the shifter in the neutral position, is one way to maintain even tire rotation and prevent a skid. A driver should practice moving the shifter into neutral before a skid occurs so, if needed, it will be a natural move.

In Summary

Ice happens. We don’t have any control over the weather or road conditions. We can maintain or regain control of a vehicle on ice by:

  1. Continuing to drive the vehicle;
  2. Braking gently, if at all;
  3. Cutting power to the drive wheels;
  4. Increasing following distances;
  5. Anticipate longer stopping distances with newer ABS equipped vehicles.

Thank you for reading this.

[subscribe2]